Cardone 26-1887 Rack and Pinion Assembly

Remanufactured Steering Rack for Pathfinder

Restore precise steering response with this remanufactured Cardone rack and pinion assembly, part number 26-1887. It is built for 1996-1999 Nissan Pathfinder models with hydraulic power steering and includes inner tie rods for the listed application.

• Fits 1996-1999 Nissan Pathfinder, N/A, without factory fender flares
• Remanufactured OE-style rack and pinion assembly for direct vehicle fit
• New spool valve seals and rack donut seals installed where applicable
• 100% replacement of rubber sealing components
• Specialized lubricant applied to support longer service life
• Protective coating helps resist corrosion and rust
• Factory test driven to verify operation and on-car communications
• Includes rack and pinion, instruction sheet

Cardone Rack and Pinion Line

Cardone’s rack and pinion assemblies are remanufactured from original equipment cores and updated with new sealing components and lubricants. Part number 26-1887 follows that process for Nissan Pathfinder steering service, with attention to fit, sealing integrity, and verified operation under load.

Detailed Product Overview

This Cardone 26-1887 rack and pinion assembly is intended for Nissan Pathfinder steering repair where the original unit has internal leakage, poor assist, or inconsistent return-to-center behavior. The assembly uses steel and aluminum construction, O-ring hose ports, M14 x 1.5 pressure and return threads, and a black protective finish. Total lock-to-lock travel is 3.25 turns, and the unit is supplied with tie rod ends included for the specified application.

This part cross-references Nissan OE numbers 485210W025 and 490010W000 for the same application.

Common Issues This Part Can Address

• Hard steering during the first few minutes of driving
• Internal bypass or fluid leakage inside the rack
• Steering that does not return to center after a turn
• Power steering pump whine caused by air in the system after service
• Wear-related steering looseness on 1996-1999 Nissan Pathfinder models

Installation Notes and Tips

For warranty purposes, Cardone recommends installing an in-line filter, using the suggested OE fluid, and flushing the system thoroughly. Bleed the steering system completely after installation to remove trapped air. If the vehicle does not return to center, inspect front-end alignment and check the return line for restriction or kinking.

Quality Assurance

Each unit is remanufactured to Cardone’s quality and performance standards and factory test driven to confirm operation under demanding conditions. Rubber sealing components are replaced, and the assembly is finished with a protective coating to help resist corrosion.