Sparta PN2034 Electric Fuel Pump - In-Tank

Electric Fuel Pump for Nissan Quest and Mercury Villager

The Sparta PN2034 is an in-tank electric fuel pump for gasoline applications, built as a standard replacement for higher-mileage and earlier model vehicles. It is a specific-fit, 12-volt turbine-style pump with a blade terminal design and a maximum pressure rating of 94 psi.

Fits 1993-1998 Nissan Quest, In-Tank. Fits 1993-1998 Mercury Villager, In-Tank. This part cross-references Bosch 69127 for the same application.

Key Features

• In-tank electric fuel pump for gas fuel systems
• Specific fit for confirmed Nissan Quest and Mercury Villager applications
• 12.0-volt operation with 2 male blade terminals
• Turbine pump design with 28.0 average flow rating
• 44 to 94 psi operating pressure range
• Includes mounting hardware, gasket/seal, isolator, hose clamps, and instruction sheet
• Nitrile rubber seal material for fuel system service

Detailed Description

Sparta PN2034 is an internal, in-tank fuel pump designed for gasoline vehicles that need a direct replacement unit with OE-focused fit and performance. It uses a turbine pump design, a hose outlet, and a strainer-style inlet, with a 22.0 mm inlet outside diameter and a 7.9 mm outlet outside diameter. The pump draws an average of 6.0 amps and is listed with a 28.0 average flow rating, making it a practical replacement for aging fuel delivery systems in the 1993-1998 Nissan Quest and 1993-1998 Mercury Villager.

Sparta, distributed by Delphi, is positioned for higher-mileage and earlier model vehicles where correct fitment and dependable fuel delivery matter. If you are replacing a worn in-tank fuel pump on a Nissan Quest or Mercury Villager, PN2034 provides the core pump assembly and the service items listed in the package contents for a cleaner repair. Part number PN2034 is also a useful reference when searching for a direct-fit electric fuel pump replacement.

Common Problems This Pump Can Address

• Hard starting caused by low fuel pressure
• Engine stalling from inconsistent fuel delivery
• Loss of power under load from a weak in-tank pump
• Fuel pump noise associated with wear
• No-start conditions related to pump failure

Installation Notes and Tips

Install PN2034 in the tank position only and verify the vehicle uses a gasoline fuel system. Confirm the 2-terminal blade connector, hose outlet connection, and 12-volt electrical setup before installation. Replace the seal during service and inspect the tank module, wiring, and fuel lines for wear or contamination while the pump is out.

For best results, clean the tank area before opening the fuel system and verify pressure after installation. The included instruction sheet should be followed during assembly and priming. PN2034 is a specific-fit replacement, so match the vehicle application carefully before ordering.

Quality Assurance

Sparta is distributed by Delphi, an OE fuel system supplier with application knowledge in fuel delivery components. PN2034 is built as a standard replacement electric fuel pump for confirmed fitment on the Nissan Quest and Mercury Villager applications listed above.